2019 Toyota RAV4: Common Problems, Recalls and Vehicle Data
Check the 2019 Toyota RAV4 records before a viewing: recall campaigns,
owner-reported symptoms, investigations, service bulletins and EPA fuel economy.
The 2019 Toyota RAV4's public record includes seven recall campaigns, and they are notably spread across different systems rather than concentrated in one: equipment labeling (two campaigns), back over prevention, engine and engine cooling, suspension, steering, and the gasoline fuel system are each represented. That breadth means the recall history touches many separate components rather than pointing to one recurring weak point. No repeat-repair campaigns appear in this record, and there are no open investigations listed for this model year.
Turning to complaints, NHTSA logged 897 for this model year. Nearly half, 428, fall under the broad "other" category, which does not point to a specific system. Among the more specific categories, engine-related complaints are next largest at 167 (19 percent), followed by electrical complaints at 90 (10 percent) and drivetrain at 79 (9 percent). The remaining categories, including steering, brakes, airbag, visibility and lighting, and fuel system, are each in the low single digits.
Separately, manufacturer service bulletins for this model year total 266, with the largest clusters concerning equipment (33) and the electrical system (31). Bulletins are not recalls; they reflect guidance issued to dealers for addressing reported symptoms, not confirmed defects or safety actions.
Complaint counts reflect how often issues were reported to NHTSA, not a defect rate or how many vehicles were actually affected.
Body class
SUV
Drive types
All-Wheel Drive, Front-Wheel Drive
Combined MPG
28–40
Recall campaigns
7
Check the VIN to find out whether a recall applies to this car. Complaint counts describe reports on
file; differences in time on the road, sales and reporting prevent a direct comparison of failure odds.
Read our methodology.
Complaint trends
898 complaints on file with NHTSA's
Office of Defects Investigation, grouped into CarTold's broad component categories.
Other428 (48%)
Engine167 (19%)
Electrical91 (10%)
Drivetrain79 (9%)
Steering32 (4%)
Brakes31 (3%)
Airbag29 (3%)
Visibility & lighting24 (3%)
Fuel system17 (2%)
Most frequently reported, by the specific component NHTSA logged each complaint
under (not CarTold's category groupings above):
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Campaign 20V3730002020-06-24
STEERING:ELECTRIC POWER ASSIST SYSTEM
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
Campaign 20V2860002020-05-20
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
Campaign 20V0640002020-02-06
ENGINE AND ENGINE COOLING
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
Campaign 19V5760002019-08-06
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 RAV4 and RAV4 Hybrid vehicles. Due to a damaged electrical connector, the back-up camera may not activate when the vehicle is in reverse. As such, these vehicles fail to comply to Federal Motor Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: If the backup camera system does not activate and the driver does not check his/her surroundings while reversing, there is an increased risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the back-up camera system and replace the audio display unit, if necessary, free of charge. The recall began September 27, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0N.
Campaign 19V5030002019-06-28
EQUIPMENT:OTHER:LABELS
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Campaign 19V2440002019-03-27
EQUIPMENT:OTHER:LABELS
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
A model-year recall does not mean every vehicle is affected. Look up a specific car with our
recall check — paste a VIN and it lists every campaign covering that
vehicle. Whether the work was actually done needs
nhtsa.gov/recalls or the
manufacturer; our guide explains
what each of its answers means.
Investigations
No NHTSA investigations on file for this model year.
Manufacturer communications
Expand a component group to read the service bulletins and other communications
manufacturers filed with NHTSA. Use the document number to ask a dealer whether the instructions apply to
this car and whether any repair is covered. A bulletin alone does not establish payment eligibility.
How these records differ from recalls and investigations.
NHTSA crash-tests each body-style/drivetrain configuration separately, so ratings can
differ by variant — shown as tested, not averaged. See
how the 5-star ratings work, including why an
overall score isn't the average of the three category scores.